Effects of pyrolysis and incineration on the phosphorus fertiliser potential of bio-waste- and plant-based materials.

Autor: Robinson, J.S., Leinweber, P.
In:

Waste Management

Bandangabe: 172
ISBN: 0956-053X
DOI: https://doi.org/10.1016/j.wasman.2023.10.012
Seite: 358 - 367

Einordung:
Institut: Professur Bodenkunde

Abstract:
Land application of biomass materials and their products of thermal treatment (biochars and ashes) can offset the unsustainable use of soluble P fertilisers. However, few evaluations of P fertiliser potential have systematically addressed diverse biomass types with contrasting P contents.

This paper evaluates the relative P fertiliser potential of four P-rich biowastes (animal bone, poultry manure, pig slurry, and a municipal sewage sludge) and three low-P, plant-based materials (reeds [Phragmites australis L.], rice husks [Oryza sativa L.] and cocoa prunings [Theobroma cacao L.]) and their biochars and ashes. We utilised three complementary approaches: P extractability in single solvents (2% formic and citric acids, and 1 M neutral ammonium citrate); sequential chemical P fractionation, and P dissolution/desorption kinetics.

In most cases, pyrolysis and incineration of the P-rich biowastes increased P extractability (% TP) in the single solvents, whilst decreasing water-soluble P. For pig slurry, for example, pyrolysis reduced water-soluble P 20-fold, with corresponding increases observed not only in the solvent-extractable P but also in the pool of potentially plant available, NaHCO3-Pi fraction (e.g., 17 to 35% TP). These complementary datasets were also evident for the low-P feedstocks and thermal products; e.g., pyrolysis increased the NaHCO3-Pi fraction in reed feedstock from 6 to 15% TP. For all biomass feedstocks, biochars and ashes, pseudo-second order P-release kinetics provided the best fit with the experimental data.

The data demonstrate scope for using pyrolysis to upgrade the P fertiliser value of a wide range of biomass materials whilst reducing their environmental impact.

Zur Publikation: Mitarbeiter, Projekte
Weitere Publikationen im Forschungsteilschwerpunkt